中华绒螯蟹蟹肉和蟹黄中挥发性风味物质组成

于慧子，陈舜胜*

(上海海洋大学食品学院，上海 201306)

中华绒螯蟹蟹肉和蟹黄中挥发性风味物质组成

于慧子，陈舜胜*

(上海海洋大学食品学院，上海 201306)

采用同时蒸馏萃取技术(SDE)方法提取中华绒螯蟹中的挥发性风味成分，利用气相色谱-质谱联用技术(GSMS)对提取的中华绒螯蟹蟹肉和蟹黄中挥发性风味成分进行分离鉴定。结果表明：在中华绒螯蟹中共检测到97种挥发性化合物。其中，蟹肉和蟹黄中含有的挥发性化合物的数量分别为60种和67种，仅有30种挥发性化合物被检测到同时存在于蟹黄和蟹肉中；中华绒螯蟹蟹黄和蟹肉中的挥发性成分在组成上的差别主要体现为在醇类、芳香类、烷烃类和含硫类化合物的组成上，这可能是导致中华绒螯蟹蟹黄和蟹肉香气差异的主要原因；除了组成上的差异，蟹黄中检测到的挥发性化合物的含量普遍高于蟹肉中检测到的化合物的含量。

中华绒螯蟹；同时蒸馏萃取；气相色谱-质谱联用仪；挥发性风味物质

Chinese mitten crab (Eriocheir sinensis), with its distinctive aroma and taste, has resulted in a rapid expansion of its culture in China, especially along the east coast area[1]. According to statistics from Ministry of Agriculture of China, farming of Chinese mitten crab has become the largest commercial crustacean aquaculture industry in China with an annual harvest exceeding 500 million kg in 2008.

Volatile flavor is generally regarded as an important parameter for food flavor quality. Therefore, it is important to understand the aroma compounds in food. Identification of the composition of volatiles is essential in aroma analysis. As food aroma profile is closely related to the isolation procedure, the choice of an appropriate sample preparation method becomes crucial[2]. In order to obtain more representative samples, simultaneous distillation-extraction (SDE) was widely applied in seafood flavor analysis, such as shrimp[3], salmon[4], scallop[5]and crab (Charybdis feriatus)[6].

Cooked Chinese mitten crab meat is famous for its special aroma. The crab spawn including the ovary and digestive glands is also considered as delicacy by most of theconsumers. Nevertheless, very little is known about the aroma components of cooked Chinese mitten crab meat[7], and no report on its crab spawn has been published. The objectives of this study were: (1) to separate and identify the volatile flavor compounds in Chinese Mitten Crab meat and crab spawn by SDE-GC-MS; (2) to compare the volatile flavor composition of the two concentrates.

1Materials and Methods

1.1Sample, reagents and equipments

Live female Chinese mitten crabs (average weight ca. 160 g) used in the study were bought from a Shanghai local seafood market. Crabs were rinsed with tap water to remove foreign substances, and then steamed for 15 min. After cooling at ambient temperature, crabmeat and crab spawn were respectively picked manually and further homogenized under an ice bath condition. The sample was immediately used for extraction.

2,4,6-trimethylpyridine (TMP) Sigma-Aldrich chemical Co., USA; C7-C30alkanes Sigma-Aldrich chemical Co., USA.

Model S250 SDE (with Likens-Nickerson apparatus) Anhui Youxin electrical equipment Ltd.; 6890 GC/5973 mass selective detector (MSD) equipped with a DB-5MS column (60 m×0.25 mm, 0.25 μm) Agilent Inc., USA.

1.2Extraction of volatile flavor components

Simultaneous distillation extraction (SDE) was used for the collection of aroma. Crabmeat (150 g) with 300 mL of distilled water was put into a 1-L round-bottom flask containing 54 μg of TMP. Distilled dichloromethane (35 mL) used as solvent was put in a 100-mL conical-bottom flask attached to the lower arm of the SDE apparatus because the density of dichloromethane is heavier than the density of water. Contents in the sample and solvent flasks were heated to boiling. The distillation-extraction was carried out for 2.5 h.

The SDE extracts were dried over 3 g of anhydrous sodium sulfate, then the aqueous layer in the extract was removed after being frozen at -35 ℃ overnight. The volume of SDE extracts was reduced to 2 mL in an older show fractionation apparatus, and then to exact 0.5 mL under a gentle stream of nitrogen. To improve identification in the further analysis, five extracts obtained under the same conditions were pooled and concentrated to 1 mL under a gentle steam of nitrogen and then stored at -35 ℃ for further analysis.

1.3GC-MS conditions

GC-MS was conducted using an GC-MS equipment. Each extract (0.5 μL) was injected in the split less mode (Injector temperature, 250 ℃). For detecting SDE extracts from crabmeat, oven temperature was programmed from 40℃ to 80 ℃ at 8 ℃/min with initial holded 3 min, then to 130℃ at 12 ℃/min, to 220 ℃ at 3 ℃/min, to 250 ℃ at 8 ℃/min with final holded 5 min. And for detecting SDE extracts from crab spawn, the oven temperature was programmed to remain at 40 ℃ for 3 min, increased from 40 ℃ to 250 ℃ at 5 ℃/ min with final maintained at 250 ℃ for 3 min. The carrier gas (Helium) was at 1.1 mL/min.

MS conditions were as follows: detector interface temperature, 250 ℃; ion source temperature, 230 ℃; ionization energy, 70 eV; mass range, 33-450 u; and electron multiplier voltage, 1698 V. Duplicate analyses were performed for each SDE extract.

1.4Compound identification and quantification

Compounds identification was confirmed by matching sample retention indices and mass spectra (comparison with MS spectra database Wiley 6/NIST 2005). When only MS is available for identification of a compound, it is considered as a tentative identification. RI values were determined by using C7-C30alkanes at the same chromatography conditions when detecting each SDE extract and calculated according to Van den dool et al[8]as follows:

Where tR(i)and tR(n+1)are retention times of n-alkanes eluting directly before and after the compound under the same chromatographic conditions.

Concentrations of positively identified compounds were determined by an internal standard method using the area ratio of a specific fragment area of a compound to that of the internal standard, calculated as follows[9]:

Where tR(i)is the retention time of each targetted compound (i), tR(n)and tR(n+1)are retention times of n-alkanes eluting directly before and after the compound(i) under the same chromatographic conditions.

In this study, we used TMP as the internal standard without considering calibration factors, that is, calibration factors were all considered as 1.00.

2Results and Discussion

A total of 97 compounds were identified in Chinese mitten crab (crab spawn and crabmeat), among which, 54 were identified by matching RI and mass spectrum. Sixtyseven compounds in cooked Chinese mitten crab spawn (18 aldehydes, 9 ketones, 13 alcohols, 11 alkanes, 6 aromatic compounds, 4 nitrogen-containing compounds, 1 sulfur-containing compounds, 5 miscellaneous compounds) and 60 compounds in crab meat (18 aldehydes, 9 ketones, 7 alcohols, 6 alkanes, 3 aromatic compounds, 4 nitrogen-containing compounds, 7 sulfur-containing compounds, 6 miscellaneous compounds) were identified. Thirty compounds were found in common for both extracts (Table 1).

Table 1 Volatile compounds identified in cooked Chinese mitten crab (crab spawn and crabmeat)

Table 1 (continued)

Chen et al[7]compared the volatile components of Chinese mitten crab (whole crab and crab meat) by a technique similar to what was used in the present study. They tentatively identified 86 compounds in whole crab and 83 compounds in crab meat on the basis of mass spectral data only. They also found that the concentrations of volatile compounds in whole crab were considerably greater than in crab meat. Volatile compounds from crab spawn of Chinese mitten crab were detected for the first time in the present study.

Aldehydes formed the major class in the two samples. Twenty-five aldehydes were identified with twelve ones detected in both extracts. A homologous series of n-aldehydes from C-5 to C-9 and simple unsaturated aldehydes from C-5 to C-7 were observed in both of the two extracts. These compounds could be the products of degradation or oxidation from the lipid of crabs[10]. The compounds (E,E)-2,4-heptadienal, hexanal and (E,E)-2,4-decadienal were the most abundant aldehydes in crab spawn, while in crab meat it was hexadecanal. The presence of alkanals, alkenals and alkadienals identified in crab might be due to oxidation of polyunsaturated fatty acids[11]. Most of the alkanals and alkenals are known to contribute fatty-oily, slightly rancid odors, and the alkadienals contribute pleasant fried-fatty aromas[12]. Nevertheless, some aldehyes with unpleasant odors were reported as important precursors to heterocyclic compounds[13]. It is interesting to note that the aldehydes shown in Table 1, except for hexadecanal, were detected in larger amounts in crab spawn than in crabmeat.

Of the ketones, nine were detected with six detected in both. Generally, lower aroma threshold volatile ketones result in greater contributions to overall fresh fish-like odors[14]. It ,s reported that ketones were mostly produced from thermal oxidation of polyunsaturated fatty acid or amino acid degradation[15]. The most abundant compounds among identified ketones in both of the SDE extracts was 2,3-butanedione. This compound was also predominant in other crustaceans evaluated. It is generally known that this compound is formed via Maillard reaction. 2,3-butanedione was believed to be important in cooked crustaceans due to its potency and desirable buttery aroma[16]. Several diketones which may provide meaty and buttery notes[17]were also detected in both extracts.

Seventeen alcohols were identified. Thirteen were found in the crab spawn and 7 in the crabmeat, with only three alkenols detected in both extracts. 1-octen-3-ol and (Z,Z)-1,5-octadien-3-ol have been reported as mushroom-metallic and metallic off-flavors in crustaceans such as prawn and sand lobsters[16]. The majority of the other alcohols detected may be formed by the decomposition of hydroperoxides of fatty acids or by reduction of aldehydes. Previous study showed that volatile alcohols generally played minor roles in the overall aroma food, except in relatively high concentrations or are saturated. Alcohols mostly possess fragrant, grassy, rancid, and earthy odors[14].

Eleven alkanes were found in crab spawn and 6 were detected in crabmeat. Alkanes probably did not contribute notably to the flavor of crab meat because of their high aroma thresholds. However, there may be notable exceptions, especially among branched chain alkanes. In the present study, it was found that 2,6,10,14-tetramethylpentadecane was significantly higher in crab spawn than in crabmeat. This compound has been reported to be found in blue crab[18]and contribute a green, sweet aroma to crayfish processing waste[17].

Among the aromatics identified, 6 compounds were detected in crab spawn and 3 compounds were detected in crabmeat. Naphthalene and its isomers were detected in only crab spawn. Naphthalenes were probably acquired and accumulated in the animals from food source or environment[5]. With a mothball-like odor[19], naphthalene and 1-methylnaphthalene has been reported in lobster and crabs[6]. Three alkylbenzenes were detected only in crab spawn. The presence of alkybenzens has been reported in crustaceans such as crayfish and crabs[18].

All three pyrazines and one pyridine were detected in both crab spawn and crabmeat. Pyrazines generally provide desirable popcorn aroma to food and are formed from Maillard reaction[5]. Pyrazines and sulfur-containing compounds have been shown to play important roles in both roasted and boiled shrimp[16], and are probably important to the flavor of cooked crab.

Seven sulfur-containing compounds were identified. They were all found in crab meat, but only 2-acetylthiazole detected in crab spawn. The concentration of 2-acetylthiazole was significantly higher in crab spawn than in crabmeat. 2-acetylthiazole with meaty notes has been reported to be important for lobster`s tail meat[[15].

Five miscellaneous compounds were identified in crab spawn and 6 were detected in crabmeat, with only D-limonene were detected in both. Limonene produces an agreeable fresh,light and sweet citrusy aroma and has been reported in crayfish[12]and blue crabs[9]. Limonene was found to be almost 15 × more abundant in crab spawn than in the crabmeat. Trimethylamine, which is responsible for the fish-house like odor of seafood, is a product of microbial reduction of trimethylamine oxide[16]. But it was only detected in crabmeat and we can`t give a convictive explain.

3Conclusion

Differences in volatiles` comp osition and concentration between crab spawn and crabmeat of Chinese mitten crab were observed. Based on the types of volatile flavor compounds identified in both extracts, we can find some interesting phenomena: composition of different classes varied a lot between the two extracts, especially in alcohols, aromatic compounds and sulfur-containing compounds, among which, the number of alcohols, alkanes and aromatic compounds were detected as much as twice in crab spawn than in crabmeat. These differences may play an important role in imparting diversities to the crab spawn and crabmeat`s aroma notes. For the amounts of volatile compounds detected in both extracts, in general, abundance of most volatile compounds was comparatively lower in crabmeat than in crab spawn.

Not all volatile compounds detected necessarily contribute favorably to crab aroma. Further research is needed to access relative importance of these compounds to the Chinese mitten crab aroma.

[1]LIN Hong, LIU Yong. A pictorial series of seafood in international trade [M]. Qingdao: China Ocean University Press, 2008.

[2]ZELLNER B D, DUGO P, DUGO G, et al. Gas chromatographyolfactometry in food flavour analysis[J]. Journal of Chromatography A, 2008, 1186(1/2): 123-143.

[3]ISHIZAKI S, TACHIHARA T, TAMURA H, et al. Evaluation of odouractive compounds in roasted shrimp (Sergia lucens Hansen) by aroma extract dilution analysis[J]. Flavour Frag J, 2005, 20(6): 562-566.

[4]VARLET V, PROST C, SEROT T. New procedure for the study of odour representativeness of aromatic extracts from smoked salmon[J]. Food Chemistry, 2007, 100(2): 820-829.

[5]CHUNG H Y, YUNG I K S, MA W C J, et al. Analysis of volatile components in frozen and dried scallops (Patinopecten yessoensis) by gas chromatography/mass spectrometry[J]. Food Research International, 2002, 35(1): 43-53.

[6]CHUNG H Y. Volatile components in crabmeats of Charybdis feriatus [J]. Journal of Agricultural and Food Chemistry, 1999, 47(6): 2280-2287.

[7]CHEN Dewei, ZHANG Ming. Analysis of volatile compounds in Chinese mitten crab (Eriocheir sinensis)[J]. Journal of Food and Drug Analysis, 2006,14(3): 297-303.

[8]VANDENDOOL H, KRATZ P D. A generalization of the retention index system including linear temperature programmed gas-liquid partition chromatography[J]. Journal of Chromatography, 1963, 11: 463-471.

[9]MATIELLA J E, HSIEH T C Y. Analysis of crabmeat volatile compounds [J]. J Food Sci, 1990, 55(4): 962-966.

[10]ZHANG Xin. Food flavor chemistry[M]. Beijing: China Light Industry Press, 2009.

[11]CHA Y J, BAEK H H, HSIEH T C Y. Volatile components in flavor concentrates from crayfish processing waste[J]. Journal of the Science of Food and Agriculture, 1992, 58(2): 239-248.

[12]VEJAPHAN W, HSIEH T C Y, WILLIAMS S S. Volatile flavor components from boiled crayfish (Procambarus clarkii) tail meat[J]. J Food Sci, 1988, 53(6): 1666-1670.

[13]CHA Y J, CADWALLADER K R. Volatile components in salt-fermented fish and shrimp pastes[J]. J Food Sci, 1995, 60(1): 19-24.

[14]ALASALVAR C, TAYLOR K D A, SHAHIDI F. Comparison of volatiles of cultured and wild sea bream (Sparus aurata) during storage in ice by dynamic headspace analysis gas chromatography mass spectrometry[J]. Journal of Agricultural and Food Chemistry, 2005, 53(7): 2616-2622.

[15]CHA Y J, CADWALLADER K R, BAEK H H. Volatile flavor components in snow crab cooker effluent and effluent concentrate[J]. J Food Sci, 1993, 58(3): 525-530.

[16]BAEK H H, CADWALLADER K R. Character-impact aroma compounds of crustaceans[C]//SHAHIDI F, CADWALLADER K R. Flavor and lipid chemistry of seafoods. Washington DC: ACS Symposium Sries 674, 1997: 85-94.

[17]TANCHOTIKUL U, HSIEH T C Y. Volatile flavor components in crayfish waste[J]. J Food Sci, 1989, 54(6): 1515-1520.

[18]CHUNG H Y, CADWALLADER K R. Volatile components in bluecrab (Callinectes sapidus) meat and processing by-product[J]. J Food Sci, 1993, 58(6): 1203-1207.

[19]CADWALLADER K R, TAN Q, CHEN F, et al. Evaluation of the aroma of cooked spiny lobster tail meat by aroma extract dilution analysis [J]. Journal of Agricultural and Food Chemistry, 1995, 43(9): 2432-2437.

TS207.3

A

1002-6630(2011)08-0267-05

2010-06-12

于慧子(1985—)，女，硕士，研究方向为食品风味。E-mail：hi.hz@hotmail.com

*通信作者：陈舜胜(1956—)，男，教授，博士研究生，研究方向为水产品加工与贮藏。E-mail：sschen@shou.edu.cn